输人输出是PLC与外部设备进行信息交流的通道，其是否正常工作，除了和输入输出单元有关外，还与联接配线、接线端子、保险丝等元件状态有关。
出现输入故障时，首先检查LED电源指示器是否响应现场元件（如按钮、行程开关等）。如果输入器件被激励（即现场元件已动作），而指示器不亮，则下一步就应检查输入端子的端电压是否达到正确的电压值。若电压值正确，则可替换输入模块。若一个LED逻辑指示器变暗，而且根据编程器件监视器、处理器未识别输入，则输入模块可能存在故障。如果替换的模块并未解决问题且连接正确，则可能是机架或通信电缆出了问题。
出现输出故障时，首先应察看输出设备是否响应LED状态指示器。若输出触点通电，模块指示器变亮，输出设备不响应。那么，首先应检查保险丝或替换模块。若保险丝完好，替换的模块未能解决问题，则应检查现场接线。若根据编程设备监视器显示一个输出器被命令接通，但指示器关闭，则应替换模块。
Iwaki 30Sh 100Ohm J Cement Creamic Resistor Power
Siemens, 3RV1925-5AB, 3-Ph Feed In Terminal Screw Link Starter Contactor Line Si
TOSHIBA VLBSV-ZA04030-G VRSF-LB-15C-SBB BS SERVO MOTOR
Fanuc 90FC011-00 C42011 Drive Board Teijin Seiki
Action Instruments, Action Pak Relay 120VAC
Telemecanique, LUCA12FU, Control Unit 3-12A V
YASKAWA CACR-SR01AB2ER SERVOPACK
Allen Bradley, 47SN Photoelectric Sub-Compact Receiver
BERGER VRDM597/50LNA MOTOR
Hubbell Bryant 9630FR Flush Receptacle 30A 250V 2Pole dryer stove range oven
Allen Bradley 800F-MD3CX11 contact module latch
Balluff, BES G-E5-Y-S4, S 4 Proximity Sensor Switch 10-30VDC
OPTEX OPX-K SENSOR
Dwyer Differential Pressure Switch 10psi
Motoman, AMSL, Gear Assembly Robot Wrist
Mazak PCB D65UB002580 YS-401A 401A board card
DANAHER S21260-SRS CONTROLLER
IFM Electronic E11408 Connector Cable Quick Connect Wire Plug Extension
PARKER 14R013FC 930GSFSMMLK2.3 (4EA) VALVE
OMRON PA204R OC225 OA224 OC222 OD212 PLC
Balluff C04AEL00VY050M Sensor Cable 4P FP 5M #22AWG PVC Cordset Connector
Omni Solenoid Valve 24VDC 30-150psi 26E01039 Coil
Mitsubishi, A1SJ71QLR21, Melsec DataLink Unit
2-5/8" Taper Shank Twist Drill 31-1/4" , Chip Flute on End
YASKAWA UGRMEM-02MAKOE (WITHOUT CONNECTOR) MINERTIA MOTOR
ORIENATAL 5IK90A-A2F (UNCLEAN) MOTOR
Turck, PKG 4M-2-RS 4.4T, U Molded Cordset
Balluff, BCS001H, SKB-VA/PTFE, Capacitive Proximity Sensor
Microstar Laboratories MSXB 038 MSXB038 expansion board
IFM, EVC008, E10904, Ecomat 400 Cordset Quick Connect Cord ADOAH043MSS0005H04
MKS 627B11TDC2P (FITTING CLEAN) BARATRON [ASIS/Not change refund]
SMC MRQBS40-50CA-A73HL Rotary Cylinder 0.7MPa
Allen Bradley, 800T-PC316RAXA, Red Green Orange Amber Cluster Pilot Light PC316
INA ZARN 45105-L Axial Cylindrical Roller Needle Bearings ball screw
Schrack, EM05, EM 05, Varistor Module
Yaskawa, JUSP-ACP15GA, Motoman MRC Robot Drive Servo Drivepack Converter Unit SV
TOSHIBA VLBST-Z04030-BU BS SERVO MOTOR
ORIENTAL RKD507-A SPEED CONTROLLER
